The Battery Light comes on when car is hot has been inspected but no fault is found. What’s next?

ANSWER : A Battery Light is triggered for several reasons. When the technician says they have "plugged" it in, they may be referring to scanning the vehicle for diagnostic troubleshooting codes. This would inform them of any electrical issues the computer has detected. If the issue was a failed battery, this test would not accurately portrait it. You may want to start by replacing the battery if you haven’t already. The alternator which is responsible for charging the battery may be outside of its specifications and causing the excess strain as well. The field output from the alternator should have triggered a code in the computer. If you would like to have this taken care of for you, a certified technician from YourMechanic can come to your car’s location to diagnose and repair the Battery Light.

ANSWER : Hi and thanks for contacting Your Mechanic. If sometimes your vehicle will start with the new alternator and sometimes it won’t, then there is a loose connection in your charging system. Check all of the wires to the alternator and to the battery. Make sure that the battery cables are clean and tight. Make sure that the wires to the starter are clean and tight. A loose ground to the ignition system will cause the vehicle to not crank over. Check all of the ground wires from the battery to the starter. Make sure that they are clean and tight. If you need further assistance troubleshooting your no start situation, then seek out a technician, such as one from Your Mechanic, that can assist you.

ANSWER : First, you want to make sure your cooling system is full. Check the radiator not the coolant jug. And check it when it is cold. If it needs coolant, add some. Of course, I don’t feel this problem is an actual low coolant condition. I would expect to find an electrical failure in the instrument cluster or from a component or wiring harness that is connected to the instrument cluster.

As a technician, I have access to reports from technicians across the country. I could not find any reports of this problem, so diagnosing this will require an experienced tech as this is not a common problem. In addition, this happens at intermittent times making it difficult to recreate. The most challenging part of this diagnosis will be recreating the symptom. I suspect it has something to do with the brake switch circuitry because it only seems to happen when you have your foot on the brake. I would begin my diagnosis there with a wiring diagram and test light in hand. The brake switch, instrument cluster, and environmental controls all interact with each other. Something is crossed either because of a failed module or damaged wiring in a harness.

Aside from making sure the coolant is full, this will not likely leave you on the side of the road. If you take it in to be diagnosed, be prepared for them to spend more time than usual to figure it out. Since it isn’t a key problem, you may need to live with it until it completely fails making it much easier to diagnose. Either way, I do recommend having a certified mechanic diagnose the warning light to make sure there isn’t anything serious going on.

Good luck.

ANSWER : Of course, don’t switch gears without being fully stopped, unless your Owner’s Manual or the manufacturer has alternative advice. However, the gear shift issue has no relation to the no-start problem you are describing. Inasmuch as you only have 6,000 miles on the car, the "constant on and off" that you believe has occurred is meaningless in comparison to the expected total vehicle service life. That is, assume what you perceive as "constant on and off", during merely 6,000 miles, might be equivalent to using the car "normally" for three years. A new car should be trouble free for at least 5 years, unless there is a defect, so your "constant on and off" is not a causal factor for any fault on the vehicle. What you might have is a defect in the ignition switch, or perhaps the immobilizer system, but if the problem is not in the switch itself, clearly there is an electrical problem.

If your vehicle is under warranty, by law the dealer MUST repair the issue you are describing within a prescribed time frame and number of "attempts", otherwise the dealer will run afoul of Federal and state Lemon Laws that give you very specific rights, and recourse (contact an Attorney; we are Mechanics, NOT attorneys). Consequently, if the vehicle is still under warranty, to save yourself money do be sure to seek a resolution from the dealer. If the vehicle is not under warranty, obviously a certified Mechanic from YourMechanic could identify the electrical fault and resolve this for you. If you want to go that route, please simply request a no start diagnostic -electrical system and the responding certified mechanic will get this taken care of for you. If you have further questions or concerns, do not hesitate to re-contact YourMechanic as we are always here to help you.

ANSWER : As you may yourself have seen, there are many reports of this fault with the Civic, that is a battery or alternator is replaced only to have the warning light fail to extinguish despite checking every conceivable electrical possibility. Your only recourse is to have a certified mechanic go through that exercise with your car and that involves first attempting to "re-set" the light. If the warning light returns, the alternator output has to be carefully measured both loaded and unloaded. All terminal connections have to be verified including all grounds. Fuses have to be checked for integrity (continuity) and the possibility of shorts, in for example dash wiring, has to be checked. To request this repair, simply request an electrical components diagnostic and the responding certified mechanic will seek a resolution to this.

ANSWER : The alternator on this vehicle is computer controlled and if the alternator is not communicating to the computer then it may default to a set charging rate that will show up as good when testing using standard methods. The computer and charging system needs to be tested using a scanner that is compatible that can check and test charging rates. You most likely do have a bad alternator on the car.

ANSWER : Batteries can die due to faults in the charging system so ideally a suspected "faulty" battery should be load tested before a decision is made to condemn it. The only exception to this rule is if the battery is already clearly "old" (greater than 5 years) but even then once you put a new battery in, as a replacement for a "dead" battery, you have to comprehensively check out the charging system. Diagnostic Trouble Code P0460 will result in disruption of the dashboard fuel gauge’s ability to accurately report your tank’s fuel levels. The fuel gauge readings may be erratic, or read somewhere off scale. Vehicles equipped with a low fuel warning light feature may also suffer from erratic low fuel warnings in the event of a code P0460. Unless the P0460 code has been reported alongside other trouble code, all of the vehicle’s essential systems should otherwise function normally. I would recommend that you request a check engine light diagnostic to first resolve the fault causing the P0460 code to set. The check gas cap light warning light could be due a faulty gas cap and/or small leaks in the EVAP system.

ANSWER : Hi there:

If you recently replaced your battery, the issue may be caused by a malfunctioning alternator or other electrical component that comprises the charging system on your Nissan Sentra. The best way to find out which item specifically is faulty, is to have a professional mobile mechanic complete a car is hard to start inspection. This will allow the mechanic to determine the precise source of what’s going on with your Sentra and recommend or complete the right repairs.