Replacement AC compressor labor cost

AC not working I brought a new compressor want to change it and hear a clicking on the left side somewhere by the road or thinking is too tired not alright or something's going wrong

My car has 160000 miles.
My car has a manual transmission.

Experienced mechanics share their insights in answering this question :
The AC may have a leak somewhere that is causing the AC to cycle on and off. The compressors on these vehicles are known to go bad and contaminate the entire system with compressor internal parts. The system will need to be flushed out and may need some other components replaced to complete the job correctly. I recommend having a mechanic come and diagnose the complete AC system and then quote the needed repairs.

How to Identify and Fix Common car Problems ?

Our sources include academic articles, blog posts, and personal essays from experienced mechanics :

Prices vary depending on HVAC type, but compressors generally range from $800–$3,000. For repairs, most technicians charge between $100 and $150 per hour. Labor for compressor replacement can cost between $400 and $1,200.
Labor Costs For AC Compressor Replacement

The labor cost to replace your ac compressor is calculated by the hourly rate and how long it takes for your make, model, and year. The cost of labor when repairing an AC Compressor is usually between $200 and $500 dollars.

Repair. If the problem is minor, repairing the compressor is often less expensive than replacing it. While the cost to replace an AC compressor runs $1,200 nationally, repairing the compressor could run between $75 and $150.
Average cost to repair a car AC

AC repair costs can vary widely, depending on the cause of the problem and the type of vehicle. On average, car AC repair costs run between about $430 and $520. However, if you need a new compressor, you can expect to spend $1,300 to $2,500 or more.

It entails removing and disposing of any remaining refrigerant, disconnecting and removing the old compressor, installing the new one with proper fittings, and recharging with refrigerant. Add it all up and it typically takes four to six hours.
Generally speaking, to have a shop properly change an AC compressor and related components, flush, and re-fill the AC system will run between $750 – 1500.00.
The average cost to replace a car a/c compressor is around $1,100—your mechanic isn`t far off the mark. The cost of parts and labor can vary greatly depending on where you live. On average, the labor cost can run between $160 and $200, with the parts costing between $650 and $840.
High cost of parts: The compressor is one of the most expensive parts in an AC system, and the cost can vary depending on the make and model of the car. In addition, some compressors may require specialized tools or replacement parts that can increase the cost of the repair.
A leak that took a long time to discover may have already inflicted damage on the compressor. In these situations, the compressor can often be replaced—but this is a prohibitively expensive repair if the system is no longer under warranty.
If your leak is at a place like an air hose connection, coupling, seal, gasket or control or shut-off valves, you might be able to fix the leak by tightening the connection. Tightening parts is one of the most straightforward ways to fix air compressor leaks.
What Happens When My AC Leaks Refrigerant? Low refrigerant levels put undue stress on your compressor, since there is a change in pressure that causes the compressor to work harder. Eventually this causes the compressor to overheat, which leads to your entire unit burning out and failing.
When the air compressor goes bad, its fan blade can shoot small shards of metal throughout the system. This can damage several air conditioner parts and create refrigerant leaks. Refrigerant leaks can also be caused by a broken seal, a broken gasket, or any other component of your system.
The compressor is an expensive item to replace. Because dead compressors usually happen in old air conditioners, it`s more cost-effective to start over with a new AC rather than pay to put a new compressor into a system that`s already wasting power and a few years from the junk heap.
Your AC system`s size can impact the installation price tag of it as a whole. It also affects the cost of your AC compressor replacement. The larger your AC system, the more expensive your compressor will be since a bigger compressor is needed to circulate the refrigerant throughout the system.

Relevant Questions and Answers :

the most relevant questions and answers related to your specific issue

What would cause the clutch on an ac compressor to continue to go bad after being replaced three times?
ANSWER : The compressor clutch relay on these vehicles are a known cause of sticking on the compressor clutch and overheating the A/C compressor clutch coil. Replace the A/C relay to see if it cures the clutch going bad the next time you do a compressor clutch replacement, or replace it now if you have just replaced the clutch.

AC noisy, intermittent blows hot, not cold. If needed, what is parts and labor cost range to replace compressor?
ANSWER : It sounds like you may have a damaged AC compressor clutch. As you may know the AC Clutch is the pulley that spins with the Belt. There are two ports on the rear of the Compressor. One is a Suction Port and the other is the Discharge Port. The Suction port is going to be your larger port and the Discharge port is going to be the smaller port. Refrigerant is sucked into the Suction port, compressed and then it exits out the Discharge Port, then entering the A/C Condenser. Your vehicle’s AC Clutch consists of the Hub, the Pulley, and the coil. The front part of the A/C Clutch is the Hub. Next is the pulley, which is where the belt rides. Finally, under the pulley is the coil, also called a field coil. The Coil is a copper would wire, that functions like a magnetic coil. If the AC Compressor is powered up, electricity engages the coil, and when this happens, it also engages the pulley. The large magnet forces the hub to pull against the pulley. Since the Shaft of the AC Compressor is mated with the A/C Hub, once engaged, it begins to pump refrigerant in the system. Turning whenever the engine is cranked, the A/C Compressor Clutch Pulley will spin even if the AC Compressor is off. If the A/C System is turned on, power is sent to your A/C Compressor Clutch and it will then engage. However, if the pressure in the system (or the refrigerant level) is either too low or high, switches will kill power to the Compressor to keep from damaging it. I would suggest having a professional from YourMechanic come to your location to take a look at your vehicle.

When replacing the AC Compressor, do I need to replace both expansion valves as well or just the front
ANSWER : Hi there. Anytime you replace major air conditioning system components like the AC compressor, it’s recommended to purchase all supporting hardware and replace it at the same time. AC works as a series of individual components working efficiently together to create cool air that flows into your cabin. As such, if you’re replacing the front expansion valve, it’s a good idea to replace the rear at the same time. This increases overall efficiency of the system, reduces the potential of small component failure and allows the parts you replaced to last longer.

I had my AC compressor replaced a week ago car is now squealing very loudly.
ANSWER : If you turned on the defrost then you turned on the compressor power. The compressor would not have come on though since there is no refrigerant in the system. The belt squeal may be a belt tensioner not putting pressure on belt to keep it tight and need replaced. Have a mechanic like one from YourMechanic fix the a/c and belt squeal for you.

when I turn my ac on my cars idle drop and stalls out and the ac is hot
ANSWER : Hello, thank you for writing in. Although the pulley is still spinning, the compressor has likely failed. If it is not properly regulating pressure in the system, one of the first signs is a warm air conditioner. Considering yours is not cooling off, the pressures are not correct. If you believe the compressor is working correctly, you may want to check for a clogged line before replacing it. Keep in mind, a blocked line has likely put extra strain on the compressor, and may cause premature failure. For more help with testing or replacing the compressor, contact our service department to schedule an appointment.

Honda civic 2002 makes a lowd knocking noise when the compressor is activated. I replaced the compressor, added oil, vacuum tested
ANSWER : Hi there. Since you just replaced the compressor, it may be that the AC system is overcharged making the compressor hard to turn. It is also possible the new compressor itself is defective.The best advice we can offer here is to have one of our professional mobile mechanics come to your location and complete an AC is not working inspection. This will allow them to inspect your vehicle and determine what exactly is causing this noise and then recommend a repair that should resolve the issue. Since there are multiple possible sources, providing you a good estimate for repairing this issue would be very difficult.

2008 VW Jetta AC not cold
ANSWER : Hi Allen. By far the best way to have your AC system correctly diagnosed is by having an AC inspection completed first. By having one of our professional mobile mechanics come to your location to diagnose the issue correctly, it significantly minimizes the mistakes in completing the wrong service. In your case, the issue could be as simple as needing to have the AC system recharged, or there is an existing leak that needs to be repaired before refilling the refrigerant. Best economic bet is to have the AC inspection completed first.

If an AC compressor is bad, what else should be replaced?
ANSWER : This all depends on if the compressor came apart and sent debris throughout the entire system. If so, either the system will need to be flushed out or all of the components will need to be replaced. The next issue is your car has R12 refrigerant in it and this has to be retrofit to the replacement R134. This is a special kit to retrofit the fittings, O-rings, and other components of your vehicle.

For the compressor that is seized, you will at the very least need to replace the compressor assembly and clutch, receiver drier, expansion valve, and flush out the system. I recommend having a mechanic diagnose your vehicle to see if any other components need replaced in order to fix your air conditioner.